先张法CFRP筋预应力海水海砂混凝土板传递长度分析

doi:10.19936/j.cnki.2096-8000.20221228.005

复合材料科学与工程 ›› 2022, Vol. 0 ›› Issue (12): 37-45.DOI: 10.19936/j.cnki.2096-8000.20221228.005

先张法CFRP筋预应力海水海砂混凝土板传递长度分析

黄宇轩, 范凌云, 高婧^*

厦门大学建筑与土木工程学院,厦门361005

收稿日期:2021-10-20 发布日期:2023-02-03
通讯作者: 高婧(1979-),女,博士,副教授,主要从事拱桥计算理论、结构健康监测与CFRP在结构工程中应用方面的研究,gaojing@xmu.edu.cn。
作者简介:黄宇轩(1997-),男,硕士研究生,主要从事CFRP在结构工程中应用方面的研究。
基金资助:
国家自然科学基金联合基金项目(U2005216),中国中铁股份有限公司科技研究开发计划(2020-重点-11);福建省自然科学基金项目(2020J01010)

Analysis of transfer length of pre-tensioned prestressed CFRP bars and sea water sea-sand concrete slab

HUANG Yu-xuan, FAN Ling-yun, GAO Jing^*

School of Architecture and Civil Engineering, Xiamen University, Xiamen 361005, China

Received:2021-10-20 Published:2023-02-03

摘要/Abstract

摘要： 为了研究先张法CFRP筋预应力海水海砂混凝土板的预应力传递长度,首先进行了CFRP筋与海水海砂混凝土黏结性能的实验,通过理论分析以及有限元数值模拟,得到了影响CFRP筋与海水海砂混凝土黏结性能的主要因素及其影响机理。采用ABAQUS软件建立了先张法CFRP筋-海水海砂混凝土预应力板有限元模型,对先张法CFRP筋预应力海水海砂混凝土的传递长度进行了分析。参数分析结果表明,混凝土强度越高,预应构件的传递长度越短,这是因为黏结强度的增大使得预应力的传递距离变短;而CFRP筋与张拉控制应力的增大,都能显著增大传递长度。本文还提出了基于混凝土黏结强度下的先张法CFRP筋-海水海砂混凝土预应力构件传递长度的计算公式。

关键词: 碳纤维增强复合材料(CFRP), 海水海砂混凝土, 黏结性能, 传递长度, 参数分析

Abstract: In order to study the prestress transfer length of pretensioned CFRP tendons, the bond performance of CFRP bars and sea water sea-sand concrete is tested. According to the theoretical analysis and finite element numerical simulation, several factors affecting the bond performance of CFRP bars and sea water sea-sand concrete are analyzed. The finite element model of pre-tensioned prestressed CFRP bars and sea water sea-sand concrete slab is established by ABAQUS software, and the transfer length of pre-tension prestressed CFRP bars and sea water sea-sand concrete slab is analyzed. The results show that the higher the concrete strength is, the shorter the transfer length of the prestressed member is, because the increase of the bond strength makes the transfer distance of the prestressed shorter. The transfer length can be significantly increased with the increase of CFRP reinforcement and tension control stress. This paper also puts forward the calculation formula of the transfer length CFRP bars sea water sea-sand concrete prestressed members.

Key words: carbon fiber reinforced composite(CFRP), sea water sea-sand concrete, bond performance, transfer length, parameter analysis

中图分类号:

TB332

黄宇轩, 范凌云, 高婧. 先张法CFRP筋预应力海水海砂混凝土板传递长度分析[J]. 复合材料科学与工程, 2022, 0(12): 37-45.

HUANG Yu-xuan, FAN Ling-yun, GAO Jing. Analysis of transfer length of pre-tensioned prestressed CFRP bars and sea water sea-sand concrete slab[J]. COMPOSITES SCIENCE AND ENGINEERING, 2022, 0(12): 37-45.

参考文献

[1] MEYER K F. Transfer and development length of 0.6-inch diameter prestressing strand in high-strength lightweight concrete[D]. Georgia Institute of Technology, 2002.
[2] BUCKNER C D. A review of strand development length for pretensioned concrete members[J]. Pci Journal, 1995, 40(2): 84.
[3] LANE S N. A new development length equation for pretensioned strands in bridge beams and 211 piles[M]. USA: Federal Highway Administration, 1998: 65-67.
[4] 刘九正. 先张法混凝土构件预应力传递长度试验研究[J]. 中外公路, 2013, 33(5): 201.
[5] MITCHELL C S. A review of initial end slip as criteria of acceptable strand bond quality and the relationship between strand diameter and transfer length for prestressed concrete members[D]. University of Wyoming, 2008.
[6] CHOI W. Flexural behavior of prestressed girder with high strength concrete[D]. North Carolina State University, 2006.
[7] Guide for the design and construction of structural concrete reinforced with FRP bars: ACI Committee 440[S]. ACI 440.1R-06, U.S.A, 2006.
[8] SAEED Y M. Behavior of prestressed concrete beams with CFRP strands[D]. Portland State University, 2016.
[9] LIM E Y. Bond strength and characteristics of carbon fiber reinforced plastic (CFRP) bars in concrete beams[D]. University of Windsor,
2000.
[10] JAWDHARI A R. Behavior of RC beams strengthened in flexure with spliced CFRP Rod panels[D]. University of Kentucky, 2016.
[11] JOSHI K. Investigation of carbon fiber composite cables (CFCC) in prestressed concrete piles[D]. The Florida State University, 2013.
[12] OKELO R. Development and splice lengths criteria for straight fiber reinforced polymer composite bars in tension[D]. The University of Texas at Arlington, 2002.
[13] AMER A H. Structural behavior of concrete structures pretensioned with fiberglass tendons[D]. University of Illinois at Chicago, 1993.
[14] LIANG Y J. Ductility and damage evaluation of post-tensioned concrete beams with hybird FRP tendon[D]. University of Illinois at Chicago, 2004.
[15] 谢丽丽, 冯辉, 刘立新, 等. 先张法预应力混凝土梁钢绞线预应力传递长度的试验研究[J]. 建筑科学, 2007, 23(5): 34-36, 4.
[16] 程文瀼, 李爱群, 王铁成, 等. 混凝土结构设计原理[M]. 5版. 中国建筑工业出版社, 2011.
[17] 混凝土结构设计规范: GB 50010—2010[S]. 北京: 中国建筑工业出版, 2015.
[18] 宋泽鹏, 陆春华, 宣广宇, 等. 螺纹GFRP筋与混凝土黏结性能试验与理论计算[J]. 建筑材料学报, 2021, 24(4): 887-894.
[19] 预应力混凝土结构设计规范: JGJ 369—2010[S]. 北京: 中国建筑工业出版, 2016.

先张法CFRP筋预应力海水海砂混凝土板传递长度分析

Analysis of transfer length of pre-tensioned prestressed CFRP bars and sea water sea-sand concrete slab

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 8

编辑推荐

Metrics

本文评价

[1]	吉祥, 秦志文, 冯威, 宋笑非, 符寿军, 王国付. 槽孔尺寸对芯材力学性能的影响[J]. 复合材料科学与工程, 2022, 0(9): 62-68.
[2]	康凯, 祖磊, 吴乔国, 张骞, 张桂明. 铝合金内胆碳纤维缠绕气瓶爆破与疲劳性能研究[J]. 复合材料科学与工程, 2022, 0(8): 35-43.
[3]	张振, 廖维张, 马超. BFRP-FRCM复合层与加气砌块黏结性能试验研究[J]. 复合材料科学与工程, 2022, 0(5): 37-45.
[4]	李奔奔, 李鹏举, 詹瑒. 纤维增强复合材料约束海水海砂混凝土方柱极限应力及极限应变计算方法分析[J]. 复合材料科学与工程, 2022, 0(2): 52-55.
[5]	雷云霄, 刘生纬, 赵建昌, 张家玮, 白晟渝. CFRP-木材界面黏结剪应力-滑移关系试验研究[J]. 复合材料科学与工程, 2022, 0(11): 15-19.
[6]	马家兴, 范亚萍. 夹芯复合材料板动态特性影响参数分析[J]. 复合材料科学与工程, 2021, 0(6): 77-81.
[7]	李奔奔, 李鹏举, 詹瑒. 复材约束海水海砂混凝土圆柱极限应力及极限应变计算方法分析[J]. 复合材料科学与工程, 2021, 0(12): 19-24.
[8]	倪迎鸽,杨宇,吕毅,张伟. 声发射在复合材料损伤机理研究的应用现状及发展趋势[J]. 玻璃钢/复合材料, 2019, 0(8): 115-126.