BFRP筋再生混凝土梁抗弯性能试验研究

玻璃钢/复合材料 ›› 2017, Vol. 0 ›› Issue (12): 45-50.

BFRP筋再生混凝土梁抗弯性能试验研究

韩飞,孔祥清^*,鲍成成,刘华新

辽宁工业大学土木建筑工程学院,锦州121001

收稿日期:2017-05-22 出版日期:2017-12-20 发布日期:2017-12-20
通讯作者: 孔祥清(1982-),女,博士,副教授,主要从事新型材料及结构力学性能方面的研究,xqkong@lnut.edu.cn。
作者简介:韩飞(1993-),男,硕士研究生,主要从事结构力学性能方面的研究
基金资助:
国家自然科学基金项目(11302093);辽宁省教育厅优秀人才项目(LJQ2015047);辽宁省自然科学基金项目(SY2016001)

EXPERIMENT STUDY ON THE FLEXURAL BEHAVIOUR OF BFRP REINFORCED RECYCLED AGGREGATE CONCRETE BEAMS

HAN Fei, KONG Xiang-qing^*, BAO Cheng-cheng, LIU Hua-xin

College of Civil & Architectural Engineering, Liaoning University of Technology, Jinzhou 121001, China

Received:2017-05-22 Online:2017-12-20 Published:2017-12-20

摘要/Abstract

摘要： 通过7根玄武岩纤维(BFRP)筋再生混凝土梁和1根钢筋再生混凝土梁的抗弯性能试验,研究了不同纵筋配筋率与再生骨料取代率对BFRP筋再生混凝土梁受弯性能的影响,分析其承载力变化过程、破坏形态、挠度变形与裂缝发展情况,并与钢筋再生混凝土梁进行对比。结果表明,BFRP筋再生混凝土梁的破坏形式有少筋和超筋破坏两种,分别由BFRP筋拉断和受压区再生混凝土压碎控制。合理配筋的BFRP筋再生混凝土梁破坏前产生的挠度较大,且受拉BFRP筋的应变也较大,说明合理配筋的BRPP筋再生混凝土梁具有一定的延性,能较好地发挥两种材料的性能。BFRP筋再生混凝土梁的裂缝宽度和裂缝条数受再生骨料取代率影响较小,而受配筋率影响较大。此外,BFRP筋再生混凝土梁的初裂荷载相比钢筋再生混凝土梁略低,但极限荷载却有明显提高。

关键词: BFRP筋, 再生混凝土梁, 抗弯承载力, 配筋率, 再生骨料取代率

Abstract: This paper experimentally investigated the flexural behaviour of basalt fiber-reinforced polymer (BFRP) reinforced recycled aggregate concrete (RAC) beams. A total of eight RAC beams, including seven reinforced with BFRP and one reinforced with steel, were fabricated and tested. The paper studied the effect of the different longitudinal reinforcement ratios and replacing rate of recycled aggregate concrete on the flexural behaviour of BFRP reinforced recycled aggregate concrete beams. The flexural capacity, failure mode, flexibility deformation and crack distribution of the test beams were analyzed. The results indicate that the failure mode was under-reinforced failure or over-reinforced failure which was governed by BFRP rupture or concrete crushing, respectively. The BFRP reinforced RAC beams with reasonable reinforcement ratio would produce larger deflection deformation and strain of BFRP tendons than that of steel reinforced RAC beam before the failure. The results indcate that the BFRP reinforced RAC beam could play a good performance of the two materials with a certain degree of ductility. Compared with the replacement rate of recycled aggregates, the reinforcement ratio had a larger influnce on the width and number of cracks in BFRP reinforced RAC beams. Furthermore, it has found that the initial cracking load of BFRP reinforced RAC beams was slightly lower than steel reinforced RAC beam. Whereas, the ultimate load was improved obviously.

Key words: BFRP bar, recycled concrete beams, flexural capacity, reinforcement ratio, recycled aggregate replacement ratio

中图分类号:

TB332

韩飞,孔祥清,鲍成成,刘华新. BFRP筋再生混凝土梁抗弯性能试验研究[J]. 玻璃钢/复合材料, 2017, 0(12): 45-50.

HAN Fei, KONG Xiang-qing, BAO Cheng-cheng, LIU Hua-xin. EXPERIMENT STUDY ON THE FLEXURAL BEHAVIOUR OF BFRP REINFORCED RECYCLED AGGREGATE CONCRETE BEAMS[J]. Fiber Reinforced Plastics/Composites, 2017, 0(12): 45-50.

参考文献

[1] 肖建庄, 李佳彬, 兰阳. 再生混凝土技术研究最新进展与评述[J]. 混凝土, 2003, 57(10): 17-20.
[2] 侯星宇. 再生混凝土研究综述[J]. 混凝土, 2011(7) : 97-98.
[3] 董江峰, 侯敏, 王清远, 等. 玄武岩纤维再生混凝土的基本力学性能[J].四川大学学报: 工程科学版, 2012, 44(2) : 9-12.
[4] 刘华新, 柳根金, 王学志,等. BFRP筋再生混凝土无腹筋深梁抗剪承载力[J]. 四川大学学报(工程科学版), 2015, 47(5): 17-22.
[5] Fathifazl G, Razaqpur A G, Isgor B O, et al. Flexural performance of steel-reinforced recycled concrete beams[J]. Aci Structural Journal, 2009, 106(6): 858-867.
[6] Choi W C, Kim S W, Yun H D. Flexural performance of reinforced recycled aggregate concrete beams[J]. Magazine of Concrete Research, 2012, 64(9): 837-848.
[7] 肖建庄, 兰阳. 再生粗骨料混凝土梁抗弯性能试验研究[J]. 特种结构, 2006, 23(1): 9-12.
[8] Knaack A M, Kurama Y C. Behavior of reinforced concrete beams with recycled concrete coarse aggregates[J]. Journal of Structural Engineering, 2015, 141(3): B4014009.
[9] Ignjatovic′ I S, Marinkovic′ S B, MiŠkovic′ Z M, et al. Flexural behavior of reinforced recycled aggregate concrete beams under short-term loading[J]. Materials and Structrues, 2013, 46(6):1045-1059.
[10] Evangelista L, Brito J D. Flexural behaviour of reinforced concrete beams made with fine recycled concrete aggregates[J]. KSCE Journal of civil engineering, 2016, 1-11.
[11] 陈爱玖, 王璇, 解伟, 等. 再生混凝土梁受弯性能试验研究[J]. 建筑材料学报, 2015, 18(4): 590-594.
[12] Toutanji H A, Saafi M. Flexural behavior of concrete beams reinforced with glass fiber-reinforced polymer (GFRP) bars[J]. ACI Structural Journal, 2000, 97 (5): 712 -719.
[13] Grace N F, Soliman A K, Abdel-Sayad G, et al. Behavior and ductility of simple and continuous FRP reinforced beams[J]. Journal of Composites for Construction, 1998, 4(186): 186-194.
[14] Elgabbas F, Vincent P, Ahmed E A, et al. Experimental testing of basalt-ber-reinforced polymer bars in concrete beams[J]. Composites Part B Engineering, 2016, 91: 205-218.
[15] 薛伟辰. 不同试验方法对GFRP筋粘结强度的影响研究[J]. 玻璃钢/复合材料, 2003(5): 10-13.
[16] 高丹盈, 赵广田, Brahim B. 纤维聚合物筋混凝土梁正截面性能的试验研究[J]. 工业建筑, 2001, 31(9): 41-44.
[17] 李春霞, 丁志胜, 晏石林. 玻璃纤维筋增强混凝土梁抗弯承载力试验研究[J]. 武汉大学学报: 工学版, 2012, 45(4): 500-503.
[18] 徐新生. FRP筋力学性能及其混凝土梁受弯性能研究[D]. 天津: 天津大学, 2007.
[19] 卢俊坤. BFRP筋海砂混凝土梁受弯性能试验研究[D]. 广州: 广东工业大学, 2014.
[20] 宋洋, 张向东, 和敏,等. 玄武岩FRP筋混凝土梁抗弯性能试验研究[J]. 工程塑料应用, 2014(4): 82-85.