玻璃/亚麻纤维混杂复合材料的吸湿和动态粘弹性性能研究

玻璃钢/复合材料 ›› 2019, Vol. 0 ›› Issue (5): 38-43.

玻璃/亚麻纤维混杂复合材料的吸湿和动态粘弹性性能研究

许家宝, 周储伟^*

南京航空航天大学机械结构力学及控制国家重点实验室,南京210016

收稿日期:2018-08-20 出版日期:2019-05-28 发布日期:2019-05-28
通讯作者: 周储伟(1964-),男,博士,教授,主要从事先进复合材料性能方面的研究,zcw@nuaa.edu.cn
作者简介:许家宝(1991-),男,硕士,主要从事先进复合材料方面的研究
基金资助:
国家自然科学基金(11272147);国重开放基金(MCMS-0218G01)

STUDY ON MOISTURE ABSORPTION AND DYNAMIC VISCOELASTICITYOF GLASS/FLAX FIBER HYBRID COMPOSITES

XU Jia-bao, ZHOU Chu-wei^*

State Key laboratory of Mechanics and Control of Mechanical Structures, College ofAerospace Engineering, Nanjing University of Aeronautics and Astronautics, Nanjing 210016, China

Received:2018-08-20 Online:2019-05-28 Published:2019-05-28

摘要/Abstract

摘要： 建立了玻璃纤维/亚麻纤维混杂复合材料层合板的吸湿模型以及湿动态粘弹性模型。采用一般的质量扩散模型分析混杂复合材料层合板的不同湿扩散特性,采用三元件模型模拟混杂复合材料层合板的湿粘弹性,模型参数通过热机械动力学分析(DMTA)实验测定,引入吸湿增重率-时间等效原理,分析不同吸湿量下混杂复合材料层合板的复刚度,研究发现在吸湿早期阶段,混杂复合材料层合板(GFFG)吸湿过程是非Fick的,混杂复合材料层合板(FGGF)满足Fick湿扩散定律,当M_t为0~0.037时,混杂复合材料层合板(_s)的储能抗弯刚度降低梯度比较大,在100 Hz以后,储能抗弯刚度增长放缓。本文所建立的模型能反映出试验观测到的规律。

关键词: 混杂复合材料层合板, 湿扩散, 湿粘弹性, 吸湿增重率-时间等效原理, 复刚度

Abstract: The moisture absorption model and wet viscoelasticity of glass fiber/flax fiber hybrid composite laminates were established. The wet diffusion characteristics of hybrid composite laminates are analyzed by the general mass diffusion model. The wet viscoelasticity of hybrid composite laminates is simulated by three element model. The model parameters are measured by the thermal mechanical dynamics analysis (DMTA). Based on the principle of relative wetting weight gain time equivalence, the complex stiffness of hybrid composite laminates under different moisture absorption is analyzed.It is found that the process of absorption moisture of hybrid composite laminates (GFFG) is non Fick at the early stage of absorption moisture, and the hybrid composite laminates (FGGF) satisfy the Fick′s law of wet diffusion. When M_t is at 0~0.037, the gradient of the storage flexural stiffness of the hybrid composite laminates is larger than that of the composite laminates, and the increase of the storage flexural stiffness tends to be slow after 100 Hz. The model established in this paper can reflect the laws observed experimentally.

Key words: hybrid composite laminates, wet diffusion, wet viscoelasticity, gain rate of absorption moisture-time equivalence principle, complex stiffness

中图分类号:

TB332

许家宝, 周储伟. 玻璃/亚麻纤维混杂复合材料的吸湿和动态粘弹性性能研究[J]. 玻璃钢/复合材料, 2019, 0(5): 38-43.

XU Jia-bao, ZHOU Chu-wei. STUDY ON MOISTURE ABSORPTION AND DYNAMIC VISCOELASTICITYOF GLASS/FLAX FIBER HYBRID COMPOSITES[J]. Fiber Reinforced Plastics/Composites, 2019, 0(5): 38-43.

参考文献

[1] 姜生, 王滨立, 史加强. 亚麻纤维及织物吸湿和散湿性能的研究[J]. 黑龙江纺织, 2001, 12(4): 1-5.
[2] 陈旭, 刘燕峰, 益小苏. 苎麻纤维增强酚醛树脂基复合材料的湿热性能研究[J]. 航空材料学报, 2013, 33(2): 58-65.
[3] Freund L, Bouchart V. Hydrothermal aging of natural fibers compos-ite: determination of diffusivity parameters[C]//European Conference on Composites Materials. 2016: 1-6.
[4] Yan L, Bing X. Hydrothermal ageing mechanisms of unidirectional flax fabric reinforced epoxy composites[J]. Polymer Degradation and Stability, 2016, 2(4): 144-158.
[5] 李健, 郭星辉, 郭明涛, 等. 复合材料薄壁圆柱壳动态粘弹性模量研究[J]. 东北大学学报, 2008, 29(12): 1770-1773.
[6] 周大鹏, 许平华, 范宏. 玻纤增强酚醛树脂复合材料的粘弹性-材料储能模量模型的建立[J]. 材料科学与工程学报, 2008, 26(6): 963-966.
[7] Chandra R, Singh S P. Micromechanical damping models for fiber-reinforced composite[J]. Composites science and technology, 2002, 33(6): 787-796.
[8] Lai C, Hiltner A. Effect of confinement on the relaxation behavior of polymer[J]. Polymer, 2010, 51(8): 1820-1829.
[9] Karimi M. Diffusion in polymer solids and solutions[J]. Mass transfer in chemical engineering processes, 2011, 13(6): 17-40.
[10] Kimo C, James C. Seferis. Evaluation of thermal degradation on carbon fiber/cyanate ester composites[J]. Polymer degradation and stability, 2000, 71(3): 425-434.
[11] 益小苏, 杜善义, 张立同. 复合材料手册[M]. 北京: 化学工业出版社, 2009.
[12] 奚莺, 陈南梁. 前处理对亚麻增强热塑性复合材料力学性能的影响[J]. 纤维复合材料, 2007, 4(36): 36-39.
[13] Lia J. Effective creep behavior and complex moduli of fiber and ribbon-reinforced polymer-matrix composites[J]. Composites Science and Technology, 1994, 52(4): 615-629.
[14] 梁军, 杜善义. 粘弹性复合材料力学性能的细观研究[J]. 复合材料学报, 2001,18(1): 97-100.
[15] Mohammad T A. Micromechanical analysis of stress relaxation response of fiber-reinforced polymers[J]. Composites Science and Technology, 2009, 69(7): 1286-1292.