BFRP筋与玄武岩纤维再生混凝土粘结性能

玻璃钢/复合材料 ›› 2017, Vol. 0 ›› Issue (6): 68-74.

BFRP筋与玄武岩纤维再生混凝土粘结性能

尹甜甜,刘华新^*,孔祥清,王学志

辽宁工业大学土木建筑工程学院,锦州121000

收稿日期:2017-01-03 出版日期:2017-06-28 发布日期:2017-06-28
通讯作者: 刘华新(1966-),男,博士,教授,研究方向为新材料及新型结构。
作者简介:尹甜甜(1990-),女,硕士研究生,研究方向为新材料及新型结构。
基金资助:
辽宁省自然科学基金(2015020208)

BOND BEHAVIOR BETWEEN BFRP BARS AND BASALT FIBER REINFORCED RECYCLED AGGREGATE CONCRETE

YIN Tian-tian, LIU Hua-xin, KONG Xiang-qing, WANG Xue-zhi

Civil Engineering & Architecture College, Liaoning University of Technology, Jinzhou 121001, China

Received:2017-01-03 Online:2017-06-28 Published:2017-06-28

摘要/Abstract

摘要： 为了研究玄武岩纤维再生混凝土与BFRP筋的粘结性能,通过42个试件的中心拉拔试验,研究再生粗骨料取代率、BFRP筋的直径以及筋材的表面特征对其的影响。试验结果表明:随着再生骨料取代率的增加,峰值极限粘结应力逐渐降低,峰值滑移量呈现先减小后增大的趋势;随着BFRP筋直径的增大,粘结应力逐渐增大,与峰值粘结应力对应的峰值滑移量逐渐增大,但整体的变化范围很小;筋材的表面状况对玄武岩纤维再生混凝土与BFRP筋的粘结性能影响很大。分别采用改进BPE模型、CMR模型及连续曲线模型的计算值与实验值比较分析其极限粘结应力,依据试验结果采用非线性回归分析得出粘结-滑移本构关系模型,该模型的计算值与实验值吻合较好。

关键词: 粘结性能, 分析模型, 轴心拉拔试验, 玄武岩纤维筋直径, 再生骨料取代率

Abstract: To study the bond properties between BFRP bars and basalt fiber recycled concrete, the center pull-out test with 42 specimens was performed. The influence of the replacement ratio of recycled coarse aggregate, the diameter and the surface characteristics of the BFRP bars were studied. The results indicate that with the increase of the replacement ratio of recycled aggregate, the bond stress of peak value decreases gradually, and the peak slip decreases firstly and then increases. With the increase of the diameter of BFRP, the bond stress increases gradually, and the peak value of bond stress is gradually increased, the peak slip value corresponding to the peak bond stress is gradually increased. But the overall change range is very small. The surface condition of the BFRP bar has greatly influence on the bond behavior of the basalt fiber recycled concrete and the BFRP bar. Using the improved BPE model, CMR model, and the continuous curve model of the calculated value and the experimental value of the comparative analysis of the ultimate bond stress, the bond-slip constitutive relation model is obtained by nonlinear regression analysis, and the calculated values of the model are in good agreement with the experimental results.

Key words: bond behavior, analysis model, the test of center pull-out, the diameter of basalt fiber reinforced polymer bars, the replacement ratio of recycled aggregate

中图分类号:

TB332

尹甜甜,刘华新,孔祥清,王学志. BFRP筋与玄武岩纤维再生混凝土粘结性能[J]. 玻璃钢/复合材料, 2017, 0(6): 68-74.

YIN Tian-tian, LIU Hua-xin, KONG Xiang-qing, WANG Xue-zhi. BOND BEHAVIOR BETWEEN BFRP BARS AND BASALT FIBER REINFORCED RECYCLED AGGREGATE CONCRETE[J]. Fiber Reinforced Plastics/Composites, 2017, 0(6): 68-74.

参考文献

[1] Shen D, Ojha B, Shi X, et al. Bond stress-slip relationship between basalt fiber-reinforced polymer bars and concrete using a pull-out test[J]. Journal of Reinforced Plastics & Composites, 2016, 35(9): 747-763.
[2] Yazc S, Arel H S. The effect of steel fiber on the bond between concrete and deformed steel bar in SFRCs[J]. Construction and Building Materials, 2013, 40(98): 299-305.
[3] Won J P, Park C G, Kim H H, et al. Effect of fibers on the bonds between FRP reinforcing bars and high-strength concrete[J]. Compos Part B: Eng. 2008, 39(5): 747-755.
[4] Haddad R H, Al-Saleh R J, Al-Akhras N M. Effect of elevated temperature on bond between steel reinforcement and fiber reinforced concrete[J]. Fire Safety Journal, 2008, 43(5): 334-343.
[5] 宁喜亮, 丁一宁. 纤维对GFRP 筋与混凝土粘结及锚固性能的影响[J]. 哈尔滨工程大学学报, 2015, 36(7): 911-916.
[6] 江朝华, 赵辉, 陈达, 等. 玄武岩纤维及聚丙烯纤维对水泥砂浆性能影响的对比分析[J]. 硅酸盐通报, 2007(06): 1084-1088.
[7] 郑宇宙, 杨星, 王文炜. 纤维增强复合筋与混凝土黏结性能试验及黏结－滑移本构关系模型[J]. 工业建筑, 2015, 45(6): 1-6.
[8] Wang H L, Sun X Y, Peng G Y, et al. Experimental study on bond behaviour between BFRP bar and engineered cementitious composite[J].Construction and Building Materials, 2015, 95: 448-456.
[9] Achillides Z., Pilakoutas K. Bond Behavior of Fiber Reinforced Polymer Bars under Direct Pullout Conditions[J]. J. Compos. Constr, 2004, 8(2): 173-181.
[10] Tekle B H, Khennane A, Kayali O. Bond Properties of Sand-Coated GFRP Bars with Fly Ash-Based Geopolymer Concrete[J]. ASCE Journal of Composites for Construction, 2016, 20(5): 1-13.
[11] Robert Prince M J, Singh B. Bond behaviour of normal-and high-strength recycled aggregate concrete[J]. Structural Concrete, 2015, 16(1): 56-70.
[12] 高丹盈. B. Brahim. 纤维聚合物筋与混凝土粘结性能的影响因素[J].工业建筑, 2001, 31(2): 9-14.
[13] 薛伟辰, 郑乔文, 杨雨. 黏砂变形GFRP筋黏结性能研究[J]. 土木工程学报, 2007, 12: 59-68.
[14] 薛伟辰, 方志庆, 王圆芳, 等. 芳纶纤维塑料筋与混凝土之间的黏结强度[J]. 建筑材料学报, 2015, 18(4): 537-545.
[15] 刘华新, 邢宪才, 孟文静. BFRP筋与玄武岩纤维再生混凝土黏结性能试验研究[J]. 混凝土, 2015, 12: 93-96.
[16] 孟文静, 刘华新, 刘红艳, 等. 基于正交试验法的BFRP筋与纤维再生混凝土黏结性能研究[J]. 混凝土与水泥制品, 2015, 06: 54-57.
[17] 普通混凝土力学性能试验方法标准: GB/T 50081—2002[S]. 北京: 中国建筑工业出版社, 2011.
[18] Baena M, Torres L, Turon A, et al. Bond behaviour between recycled aggregate concrete and glass fibre reinforced polymer bars[J]. Construction & Building Materials, 2016, 106: 449-460.